电动吊篮检查验收记录表

Electric Basket Checklist Form

使用单位Subcontractor： 编号SN：

CRITICAL ASSESSMENT 严重性评估 NO.序号 ITEMS/项目 ISSUE/问题 1 Valid 3rd Party Inspection Certificate copy Attached ?/是否有有效的第三方检测证书复印件 2 产品标牌内容是否齐全（产品名称、主要技术性能、制造日期、出厂编号、制造厂名称） Product label content is complete (product name, main technical performance, manufacturing date, factory number, factory name) 吊篮主结构有无开焊或明显腐蚀，螺栓有无松动、缺损，外框有无明显变形、锈蚀 3 welding defects or obvious corrosion in the main structure of the basket, loose bolts, defect, frame has no obvious deformation, bolt corrosion have (no) loose 4 吊篮平台底板四周是否装有标准高度的踢脚板，吊兰平台底板是否有防滑措施 A platform bottom plate is fitted with the standard height of the skirting board, floor have anti-skid measures 提升机构的所有装置外露部分是否装防护装置 5 6 7 Whether the exposed part of the lifting mechanism of the lifting mechanism is fitted with a protective device 提升机的连接螺母是否紧固 Fastening of the connecting nut of the hoist 电磁制动器和机械制动器是否灵敏有效 Electromagnetic brake and mechanical brake is sensitive and effective 上、下行程限位装置是否灵敏可靠 Whether the upper and lower travel limit device is sensitive and reliable 8 9 超高限位器止挡安装在距顶端80cm处固定 The super high limit device stop is installed at the top of the 80cm. 安全锁灵敏可靠，是否在标定有效期内 The safety lock is sensitive and reliable, whether in the calibration period, 10 11 独立设置保险绳，直径不小于16mm的锦纶绳，锁绳器符合要求 Independent insurance rope, nylon rope diameter not less than 16mm, to meet the requirements of rope locking device 12 钢丝绳无断丝、磨损、扭结、变形、腐蚀、无沙砾、灰尘附着，符合吊篮安全使用要求 Wire rope broken wires wear kink deformation, corrosion, no sand, dust adhesion, meet the safety requirements of basket 13 14 钢丝绳的固定是否符合要求 Whether the wire rope is fixed to meet the requirements 钢丝绳坠重应距地15cm垂直绷紧 15cm vertical tension of wire rope falling weight 悬挂机构的零部件是否齐全正确，安装是否符合要求，钢结构有无开焊、变形、裂纹、破损 15 The parts of the suspension mechanism are complete and correct, the installation is in line with the requirements, the steel structure has no open welding, deformation, crack, damage 配重应固定牢固，重量及块数是否符合要求 16 The weight should be firmly fixed, whether to meet the requirements of weight and number 悬挂机构挑梁外伸长度及两根挑梁之间的距离是否符合标准，悬挂机构前高后低设置、纤维张紧度为前端上翘2-3cm. 17 Suspension mechanism pick overhanging beam length and two pick the distance between the beam and the compliance with the standards, the mechanism of high to low set, fiber tension for the front-end upturned 2-3cm suspension 18 19 20 21 22 电动吊篮专用箱必须有漏保Electric basket special boxes must have GFCI 电线、电缆有无破损Wires, cables are damaged 电气系统各种安全保护装置是否齐全、可靠Electrical system of various safety protection device is complete, reliable 安全带与安全绳的连接安全锁扣是否符合灵敏度的安全要求The safety belt and safety rope connecting safety lock meets the safety requirements of sensitivity 安全绳是否连接在其它的可靠连接件处The safety rope is connected with other reliable connection parts.